Combustion and Emission Performance of an HCCI Engine Fuelled by n-Heptane/Toluene Blends at a Low-Load Operating Condition

Authors

  • Hongsheng Guo Energy, Mining and Environment Research Center,Ontario K1A 0R6
  • W. Stuart Neill Energy, Mining and Environment Research Center, 1200 Montreal Road, Ottawa, Ontario K1A 0R6, Canada

DOI:

https://doi.org/10.15377/2409-5826.2018.05.3

Keywords:

Internal combustion engine, HCCI, Diesel combustion, Aromatics.

Abstract

 Homogeneous charge compression ignition (HCCI) engine technology offers high fuel efficiency and extra low nitrogen oxide (NOx) and particulate matter (PM) emissions, which makes it a potential alternative combustion mode to conventional diesel engines. A diesel fuel is usually composed of many classes of hydrocarbons among which aromatic compounds have attracted special attention due to their specific combustion characteristics. Understanding the combustion and emission characteristics of different classes of hydrocarbons is crucial for identifying appropriate diesel fuels suitable for HCCI combustion. Toluene is a typical aromatic compound in a diesel fuel. A study of toluene content may provide implications of the effect of aromatic in a diesel fuel on HCCI combustion. In this paper, the combustion and emission performance of an HCCI engine fuelled by n-heptane/toluene blends at a low load operating condition was investigated by experiment and numerical simulation. A modified Cooperative Fuel Research (CFR) engine and a in-house-developed multi-zone model were employed. The engine was operated at the condition of engine speed of 900 rpm, relative air/fuel ratio of 3.5 and without external exhaust gas recirculation. The investigated fuel blends covered a range from pure n-heptane to 70% toluene by volume. Both experimental and numerical results showed that an increase in toluene fraction in the fuel blend retarded combustion phasing. As a result, the optimal compression ratio, at which thermal efficiency reached its maximum for a fuel blend, increased with increasing toluene fraction. The maximum thermal efficiency increased as the toluene fraction increased from 0 to 50%, but then decreased with further increasing toluene fraction to higher values. The peak pressure rise rate also increased with increasing toluene fraction at a constant combustion phasing. An increase in toluene fraction resulted in an increase in unburned hydrocarbon emissions but had little effect on NOx emissions.

Author Biographies

Hongsheng Guo, Energy, Mining and Environment Research Center,Ontario K1A 0R6

National Research Council Canada, 1200 Montreal Road, Ottawa

W. Stuart Neill, Energy, Mining and Environment Research Center, 1200 Montreal Road, Ottawa, Ontario K1A 0R6, Canada

National Research Council Canada

References

Noguchi M, Tanaka Y, Tanaka T, Takeuchi Y. A study on gasoline engine combustion by observation of intermediate reactive products during combustion. 1979, SAE paper 790840. (https://saemobilus.sae.org/content/790840/)

Onishi S, Jo SH, Shoda K, Jo PD, Kato S. Active thermoatmosphere combustion (ATAC) - a new combustion process for internal combustion engines. 1979, SAE paper 790501. (https://saemobilus.sae.org/content/790501/)

Najt PM, Foster DE. Compression ignited homogeneous charge combustion. 1983, SAE paper 830264. (https://saemobilus.sae.org/content/830264/)

Westbrook CK. Chemical kinetics of hydrocarbon ignition in practical combustion systems. Proc Comb Inst 2000, 28, 1563-1577. (https://www.sciencedirect.com/science/article/pii/S0082078400805548/pdf?md5=d970b2f72d0acbaedbf21dea39482f53&pid=1-s2.0-S0082078400805548-main.pdf).

Epping K, Aceves S, Bechtold R, Dec J. The potential of HCCI combustion for high efficiency and low emissions. 2002, SAE paper 2002-01-1923. (https://saemobilus.sae.org/content/2002-01-1923/)

Hosseini V, Neill WS, Guo H, Dumitrescu CE, Chippior WL, Fairbridge C, Mitchell K. Effects of cetane number, aromatic content and 90% distillation temperature on HCCI combustion of diesel fuels. 2010, SAE paper 2010-01-2168. (https://saemobilus.sae.org/content/2010-01-2168/)

Andrae J, Johansson D, Björnbom P, Risberg P, Kalghatgi G. Co-oxidation in the auto-ignition of primary reference fuels and n-heptane/toluene blends. Combustion and Flame 2005,140, 267-286. (https://www.sciencedirect.com/-science/article/pii/S0010218004002330/pdfft?md5=e72e94868d5b3c8f6323daa234aecf94&pid=1-s2.0-S0010218004002330-main.pdf) https://doi.org/10.1016/j.combustflame.2004.11.009

Andrae JGG, Brinckb T, Kalghatgi GT. HCCI experiments with toluene reference fuels modeled by a semidetailed chemical kinetic model. Combustion and Flame 2008;155: 696-712. (http://ja6yb8mj3u.search.serialssolutions.com/?V=1.0&N=100&tab=JOURNALS&L=JA6YB8MJ3U&S=T_W_A&C=Combustion+and+Flame) https://doi.org/10.1016/j.combustflame.2008.05.010

Sakai Y, Ozawa H, Ogura T, Miyoshi A, Koshi M, Pitz WJ. Effects of toluene addition to primary reference fuel at high temperature. 2007, SAE paper 2007-01-4104. (https://saemobilus.sae.org/content/2007-01-4104/)

Xiao Z, Ladommatos N, Zhao H. The effect of aromatic hydrocarbons and oxygenates on diesel engine emissions. Proc Instn Mech Engrs 2000, 214D, 307-332. https://doi.org/10.1243/0954407001527448

Szybist JP, Bunting BG. The effects of fuel composition and compression ratio on thermal efficiency in an HCCI engine. 2007, SAE paper 2007-01-4076. (https://saemobilus.sae.org/content/2007-01-4076/)

Guo H, Hosseini V, Neill WS, Chippior WL, Dumitrescu CE. An experimental study on the effect of hydrogen enrichment on diesel fuelled HCCI combustion. Int J Hydrogen Energy 2011, 36, 13820-13830. (http://ja6yb8mj3u.search.serialssolutions.com/?V=1.0&N=100&tab=JOURNALS&L=JA6YB8MJ3U&S=T_W_A&C=International+Journal+of+Hydrogen+Energy) https://doi.org/10.1016/j.ijhydene.2011.07.143

Guo H, Li H, Neill WS. A study on the performance of combustion in a HCCI engine using n-heptane by a multizone model. 2009, ASME Internal Combustion Engine Division 2009 Fall Technical paper ICEF2009-14117.

Smith GP, Golden DM, Frenklach M, Moriarty NW, Eiteneer B, Goldenberg M. et al. http://www.me.berkeley.edu/-gri_mech/.

Hsu BD. Heat release, cycle efficiency and maximum cylinder pressure in diesel engine: the use of an extended air cycle analysis. SAE Transactions 1984, 93, 4.766-4.778.

Guo H, Liu F, Smallwood GJ. A numerical study on NOX formation in laminar counterflow CH4/air triple flames. Combustion and Flame 2005, 143, 282-98. (http://ja6yb8mj3u.search.serialssolutions.com/?V=1.0&N=100&tab=JOURNALS&L=JA6YB8MJ3U&S=T_W_A&C=Combustion+and+Flame) https://doi.org/10.1016/j.combustflame.2005.06.004

Guo H, Neill WS, Li H. On the formation of NOx and N2O in an HCCI engine fuelled with n-heptane. 2010 Spring Technical Meeting of the Combustion Institute/Canadian Section, 2010.5, Ottawa, Canada.

Downloads

Published

2018-07-12

How to Cite

1.
Hongsheng Guo, W. Stuart Neill. Combustion and Emission Performance of an HCCI Engine Fuelled by n-Heptane/Toluene Blends at a Low-Load Operating Condition. J. Adv. Therm. Sci. Res. [Internet]. 2018Jul.12 [cited 2021Sep.26];5(1):17-26. Available from: https://www.avantipublishers.com/jms/index.php/jatsr/article/view/866

Issue

Section

Articles