Gasification of Biomass in an Updraft Fixed Bed Reactor: Effect of Viscous Models

Authors

  • F. J. Alarcón-Gaete Universidad De Chile, Beauchef 851, Santiago, Chile
  • J. C. Elicer-Cortés Universidad De Chile, Beauchef 851, Santiago, Chile

DOI:

https://doi.org/10.15377/2409-5826.2016.03.02.01

Keywords:

CFD, euler-euler approach, multiphase flow, fixed bed, updraft gasifiers, biomass fuel.

Abstract

 A numerical study to investigate the influence of viscous models in the biomass gasification in an updraft fixed bed reactor is presented. The unsteady simulations were performed using finite volume method of ANSYS Fluent. A two-dimensional axisymmetric transient model was used to simulate the biomass gasification process. The model is based on the Euler-Euler multiphase formulation. The reactive gas-solid flow considers both homogeneous and heterogeneous reactions (drying, pyrolysis, combustion and gasification). Source terms and chemical kinetics are incorporated into the code using user-defined functions programmed in C. Results are validated with experimental data available in the literature for gasification in a continuous reactor. Temperatures and mole fractions of CO, CO2, CH4, Tar, and H2 at the reactor exit are in good agreement with the experimental measurements. Laminar model is agreed with experimental data for net calorific value, however, discrepancies are observed when the mixture model is used. This work provides a methodology for studying gasification in fixed beds using a commercial CFD code which can be used in gasifier design, analysis, and optimization.

Author Biographies

F. J. Alarcón-Gaete, Universidad De Chile, Beauchef 851, Santiago, Chile

Departamento De Ingeniería Mecánica

J. C. Elicer-Cortés, Universidad De Chile, Beauchef 851, Santiago, Chile

Departamento De Ingeniería Mecánica

References

Desrosiers RE and Lin RJ. A moving-boundary model of biomass pyrolysis, Sol. Energy 1984; 33: 187-196. http://dx.doi.org/10.1016/0038-092X(84)90237-8

Sharma AK. Equilibrium modeling of global reduction reactions for a downdraft (biomass) gasifier. Energy Convers Manag 2008; 49: 832-842. http://dx.doi.org/10.1016/j.enconman.2007.06.025

Kayal TK, Chakravarty M and Biswas GK. Mathematical modelling of continuous updraft gasification of bundled jute stick -- a low ash content woody biomass. Bioresour Technol 1994; 49: 61-73. http://dx.doi.org/10.1016/0960-8524(94)90174-0

Mikulandrić R, Lončar D, Böhning D, Böhme R and Beckmann M. Artificial neural network modelling approach for a biomass gasification process in fixed bed gasifiers. Energy Convers Manag 2014. http://dx.doi.org/10.1016/j.enconman.2014.03.036

Mahmoudi AH, Hoffmann F and Peters B. Detailed numerical modeling of pyrolysis in a heterogeneous packed bed using XDEM. J Anal Appl Pyrolysis 2014; 106: 9-20. http://dx.doi.org/10.1016/j.jaap.2013.12.001

Fletcher DF, Haynes BS, Christo FC and Joseph SD. A CFD based combustion model of an entrained flow biomass gasifier. Appl Math Model 2000; 24: 165-182. http://dx.doi.org/10.1016/S0307-904X(99)00025-6

Ismail TM and El-Salam MA. Numerical and experimental studies on updraft gasifier HTAG. Renew Energy 2015; 78: 484-497. http://dx.doi.org/10.1016/j.renene.2015.01.032

Gómez-Barea A and Leckner B. Modeling of biomass gasification in fluidized bed. Prog Energy Combust Sci 2010; 36: 444-509. http://dx.doi.org/10.1016/j.pecs.2009.12.002

Mendes A, Dollet A, Ablitzer C, Perrais C and Flamant G. Numerical simulation of reactive transfers in spouted beds at high temperature: Application to coal gasification. J Anal Appl Pyrolysis 2008; 82: 117-128. http://dx.doi.org/10.1016/j.jaap.2008.02.001

Salam PA and Bhattacharya SC. A comparative study of charcoal gasification in two types of spouted bed reactors. Energy 2006; 31: 228-243. http://dx.doi.org/10.1016/j.energy.2005.01.004

Xia Z, Fan Y, Wang T, Guo X and Chen C. A TFM-KTGF jetting fluidized bed coal gasification model and its validations with data of a bench-scale gasifier. Chem Eng Sci 2015; 131: 12-21. http://dx.doi.org/10.1016/j.ces.2015.03.017

Mandl C, Obernberger I and Biedermann F. Modelling of an updraft fixed-bed gasifier operated with softwood pellets. Fuel 2010; 89: 3795-3806. http://dx.doi.org/10.1016/j.fuel.2010.07.014

Umeki K, Namioka T and Yoshikawa K. Analysis of an updraft biomass gasifier with high temperature steam using a numerical model. Appl Energy 2012; 90: 38-45. http://dx.doi.org/10.1016/j.apenergy.2010.12.058

Lucas C. High temperature air/steam gasification of biomass in an updraft fixed bed batch type gasifier. Royal Institute of Technology 2005.

Yang W, Ponzio A, Lucas C and Blasiak W. Performance analysis of a fixed-bed biomass gasifier using hightemperature air. Fuel Process Technol 2006; 87: 235-245. doi:10.1016/j.fuproc.2005.08.004. http://dx.doi.org/10.1016/j.fuproc.2005.08.004

Di Blasi C, Signorelli G and Portoricco G. Countercurrent Fixed-Bed Gasification of Biomass at Laboratory Scale. Ind Eng Chem 1999; 38: 2571-2581. http://dx.doi.org/10.1021/ie980753i

Blasi CD. Dynamic behaviour of stratified downdraft gasifiers. In Chem Eng Sci 2000: 2931-2944. http://dx.doi.org/10.1016/S0009-2509(99)00562-X

Tinaut FV, Melgar A, Pérez JF and Horrillo A. Effect of biomass particle size and air superficial velocity on the gasification process in a downdraft fixed bed gasifier. An experimental and modelling study. Fuel Process Technol 2008; 89: 1076-1089. http://dx.doi.org/10.1016/j.fuproc.2008.04.010

Gerun L, Paraschiv M, Vîjeu R, Bellettre J, Tazerout M, Gøbel B, et al. Numerical investigation of the partial oxidation in a two-stage downdraft gasifier. Fuel 2008; 87: 1383-1393. http://dx.doi.org/10.1016/j.fuel.2007.07.009

Wu Y, Zhang Q, Yang W and Blasiak W. Two-Dimensional Computational Fluid Dynamics Simulation of Biomass Gasification in a Downdraft Fixed-Bed Gasifier with Highly Preheated Air and Steam. Energy and Fuels 2013; 27: 3274-3282. http://dx.doi.org/10.1021/ef4003704

Manchasing C, Kuchonthara P, Chalermsinsuwan B and Piumsomboon P. Experiment and computational fluid dynamics simulation of in-depth system hydrodynamics in dual-bed gasifier. Int J Hydrogen Energy 2013; 38: 10417-10430. http://dx.doi.org/10.1016/j.ijhydene.2013.06.033

Kær SK. Straw combustion on slow-moving grates - A comparison of model predictions with experimental data. Biomass and Bioenergy 2005; 28: 307-320. http://dx.doi.org/10.1016/j.biombioe.2004.08.017

de Souza-Santos ML. Solid Fuels Combustion and Gasification: Modeling, Simulation and Equipment Operations Second Edition. CRC Press 2010. https://books.google.com/books?id=8_rLBQAAQBAJ&pgis=1 (accessed September 9, 2015). http://dx.doi.org/10.1201/9781420047509

Thunman H, Niklasson F, Johnsson F and Leckner B. Composition of volatile gases and thermochemical properties of wood for modeling of fixed or fluidized beds. Energy and Fuels 2001; 15: 1488-1497. http://dx.doi.org/10.1021/ef010097q

Di Blasi C. Modeling wood gasification in a countercurrent fixed-bed reactor. AIChE J 2004; 50: 2306-2319. http://dx.doi.org/10.1002/aic.10189

Rath J and Staudinger G. Cracking reactions of tar from pyrolysis of spruce wood. Fuel 2001; 80: 1379-1389. http://dx.doi.org/10.1016/S0016-2361(01)00016-3

Yang YB, Yamauchi H, Nasserzadeh V and Swithenbank J. Effects of fuel devolatilisation on the combustion of wood chips and incineration of simulated municipal solid wastes in a packed bed. Fuel 2003; 82: 2205-2221. http://dx.doi.org/10.1016/S0016-2361(03)00145-5

Bin Yang Y, Ryu C, Sharifi VN and Swithenbank J. Effect of Model and Operating Parameters on Air Gasification of Char. Energy and Fuels 2006; 20: 1698-1708. http://dx.doi.org/10.1021/ef060036y

Di Blasi C. Modeling chemical and physical processes of wood and biomass pyrolysis. Prog Energy Combust Sci 2008; 34: 47-90. http://dx.doi.org/10.1016/j.pecs.2006.12.001

Cao Y, Wang Y, Riley JT and Pan WP. A novel biomass air gasification process for producing tar-free higher heating value fuel gas. Fuel Process Technol 2006; 87: 343-353. http://dx.doi.org/10.1016/j.fuproc.2005.10.003

Di Blasi C, Signorelli G, Di Russo C and Rea G. Product Distribution from Pyrolysis of Wood and Agricultural Residues. Ind Eng Chem Res 1999; 38: 2216-2224. http://dx.doi.org/10.1021/ie980711u

ANSYS I. ANSYS FLUENT Theory Guide. Release 2009; 12.

Krishnamoorthy G, Rawat R and Smith PJ. Parallelization of the P-1 Radiation Model. Numer Heat Transf Part B Fundam 2007.

Huilin L and Gidaspow D. Hydrodynamics of binary fluidization in a riser: CFD simulation using two granular temperatures. Chem Eng Sci 2003; 58: 3777-3792. http://dx.doi.org/10.1016/S0009-2509(03)00238-0

Syamlal M, Rogers W and O`Brien TJ. MFIX documentation theory guide 1993. http://dx.doi.org/10.2172/10145548

Gunn DJ. Transfer of heat or mass to particles in fixed and fluidised beds. Int J Heat Mass Transf 1978; 21: 467-476. http://dx.doi.org/10.1016/0017-9310(78)90080-7

Downloads

Published

2016-12-13

How to Cite

1.
F. J. Alarcón-Gaete, J. C. Elicer-Cortés. Gasification of Biomass in an Updraft Fixed Bed Reactor: Effect of Viscous Models. J. Adv. Therm. Sci. Res. [Internet]. 2016Dec.13 [cited 2021Sep.26];3(2):46-57. Available from: https://www.avantipublishers.com/jms/index.php/jatsr/article/view/858

Issue

Section

Articles